The National Highway Traffic Safety Administration (NHTSA) lists 6 official safety recall campaigns for the 2018 Chevrolet Express in AutoUtility's current federal dataset. The primary affected vehicle systems include Other / Miscellaneous, Wheels & Tires, Electrical System.
Key Recall Findings
- • Official Recall Campaigns: 6 campaigns on file with NHTSA
- • Primary Affected Subsystems: Other / Miscellaneous, Wheels & Tires, Electrical System
- • Official Remedy: Detailed per campaign in official NHTSA records below
- • Most Recent NHTSA Report: February 25, 2021
VIN-Specific Notice: Safety recall campaigns apply to specific production date ranges and vehicle identification numbers (VINs). A campaign listing on this model-year page does not establish that every vehicle or trim is affected. Check your 17-digit VIN at NHTSA.gov or with an authorized dealer to verify whether a safety repair is needed.
Vehicle Subsystem 2 campaigns
Other / Miscellaneous
Vehicle Subsystem 2 campaigns
Wheels & Tires
Vehicle Subsystem 1 campaign
Electrical System
Vehicle Subsystem 1 campaign
Visibility, Wipers & Glass
Domain Mapping Methodology: A single NHTSA recall campaign may involve more than one vehicle subsystem (such as electrical wiring affecting fuel delivery), so domain totals can exceed the total number of unique recall campaigns. Complaint and recall counts are grouped by broad vehicle system; component co-occurrence does not establish that an individual owner complaint is related to a specific recall campaign.
NHTSA Campaign #21V115000 Wheels & Tires
Affected Component: TIRES
NHTSA Report Date: February 25, 2021
Safety Defect Summary: General Motors LLC (GM) is recalling certain 2020 Buick Enclave, Cadillac XT4, XT5, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, Traverse, GMC Yukon, Yukon XL, 2018-2021 Chevrolet Express, GMC Savana, 2019-2020 Chevrolet Blazer, Silverado 1500, GMC Acadia, Sierra 1500, and certain Continental tires sold to the aftermarket for various model year 2018-2021 vehicles. The affected tires were cured for too long during production.
Safety Risk / Consequence: Over cured tires may develop a break in the sidewall resulting in sudden air loss or a belt edge separation which could lead to a tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Authorized Remedy Instructions: GM will notify owners, and dealers will inspect the tires, replacing them as necessary, free of charge. The recall began March 22, 2021. Owners may contact GMC customer service at 1-888-988-7267, Buick customer service at 1-866-608-8080, Chevrolet customer service at 1-800-222-1020 or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212329050.
Manufacturer & NHTSA Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Campaign #19V428000 Other / Miscellaneous
Affected Component: EQUIPMENT
NHTSA Report Date: June 11, 2019
Safety Defect Summary: Unicell Body Company Inc. (Unicell) is recalling certain 2017-2019 Chevrolet Express and GMC Savanna, 2018-2019 Hino 155, Ford Econoline and Transit and Isuzu NPR, and 2018 Ram ProMaster-based vehicles equipped with ASA Electronics Voyager monitors used to display the back-up camera image. The affected monitors may revert back to the factory default settings which may cause the camera image to be reversed.
Safety Risk / Consequence: The driver may inadvertently turn the wrong direction to avoid an object behind the vehicle, increasing the risk of a crash.
Authorized Remedy Instructions: Unicell will work with ASA Electronics to notify owners and offer a remedy, free of charge. The recall began May 9, 2019. Owners may contact ASA Electronics customer service 1-800-384-4400 or Unicell at 1-716-853-8628.
Manufacturer & NHTSA Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Campaign #19V387000 Visibility, Wipers & Glass
Affected Component: VISIBILITY:GLASS, SIDE/REAR
NHTSA Report Date: May 23, 2019
Safety Defect Summary: General Motors LLC (GM) is recalling certain 2016-2019 Chevrolet Express and GMC Savana vehicles. One or both of the rear-quarter windows may be tempered glass instead of laminated glass. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 226, "Ejection Mitigation."
Safety Risk / Consequence: Tempered glass increases the risk of injury in the event of a side impact or rollover crash.
Authorized Remedy Instructions: GM will notify owners, and dealers will replace the tempered glass windows with laminated glass windows, as necessary, free of charge. The recall began July 5, 2019. Owners may contact GM customer service at 1-586-596-1733. GM's number for this recall is N192218960.
Manufacturer & NHTSA Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Campaign #18V655000 Electrical System
Affected Component: ELECTRICAL SYSTEM
NHTSA Report Date: September 21, 2018
Safety Defect Summary: General Motors LLC (GM) is recalling certain 2016-2018 Chevrolet Express and GMC Sierra vehicles equipped with a single, manual, rear climate control module (CCM). If the temperature is set to maximum heat or the mode knob is set to maximum floor vent and an electrical short occurs, components within the CCM may overheat.
Safety Risk / Consequence: If the CCM overheats, there is an increased risk of a fire in the vehicle's headliner.
Authorized Remedy Instructions: GM will notify owners, and dealers will remove the electrical insulation from a wiring connector within the CCM to remove the fire risk, free of charge. The recall began November 6, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 18299.
Manufacturer & NHTSA Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Campaign #18V509000 Wheels & Tires
Affected Component: TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
NHTSA Report Date: August 2, 2018
Safety Defect Summary: General Motors LLC (GM) is recalling certain 2018 Chevrolet Express and GMC Savana vehicles with certain combinations of front-tire and gross-vehicle-weight option codes. The Tire Pressure Monitoring System (TPMS) may be incorrectly calibrated, causing the TPMS warning lamp to illuminate when tire pressure reaches 37 PSI, not 41 PSI. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."
Safety Risk / Consequence: If the low tire pressure telltale is not illuminated at the correct tire pressure, the driver may have less time to react to a low-tire-pressure situation, which could affect the driver's ability to control the vehicle in certain situations and could increase the risk of a crash.
Authorized Remedy Instructions: GM will notify owners, and dealers will check the PSI information on the remote control door lock receiver (RCDLR) and tire placard match, and if the information is different the RCDLR will be reprogrammed. This repair will be done free of charge. The recall began August 27, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18255.
Manufacturer & NHTSA Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
NHTSA Campaign #18V267000 Other / Miscellaneous
Affected Component: EQUIPMENT
NHTSA Report Date: April 26, 2018
Safety Defect Summary: General Motors LLC (GM) is recalling certain 2009-2014 Chevrolet Silverado HD and GMC Sierra HD, 2009 GMC Topkick 5000, 6000, 7000 and 8000 Series and Isuzu F Series, and 2009-2018 Chevrolet Express, and GMC Savana vehicles, equipped with certain Plastic-Handle Fire Extinguishers or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Safety Risk / Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Authorized Remedy Instructions: GM will notify owners, instructing them to contact Kidde to get a replacement fire extinguisher, free of charge. The recall began June 11, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Isuzu customer service at 1-866-441-9638. GM's number for this recall is 18146.
Manufacturer & NHTSA Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Source Data Notice: Campaign summaries, safety consequences, and remedy descriptions are direct text extracts published by the National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation.
Historical Reporting Note: Recall campaign counts are shown by model year and should not be interpreted as a vehicle reliability score. Campaigns may cover multiple model years, and newer model years naturally have had less calendar exposure time for new safety campaigns to be issued.
Safety recall campaigns on this page are associated with this make, model, and model year in NHTSA federal records. A campaign may apply only to certain vehicles based on production date, equipment, manufacturing details, or other campaign-specific criteria.
AutoUtility cannot determine whether a particular VIN is affected or whether a recall remedy has already been completed.
For vehicle-specific recall status, check the 17-digit VIN using NHTSA's official recall lookup or contact an authorized dealer. Campaign-specific remedy information shown above is reproduced from official NHTSA recall records.
Official NHTSA Safety Resources:
NHTSA Vehicle Safety Hotline: 1-888-327-4236 (TTY: 711)