2023 Tesla Model 3 Problems & Defect Complaints

"On 8/24/2026 at approximately 12:02pm, my 2023 Model 3 was parked in my assigned space in a covered apartment carport, with a concrete support pillar approximately one to two feet from the passenger side. I entered a destination and activated FSD (Supervised) from Park, a Tesla-designed feature...."

"I am writing to report several safety incidents that occurred while using Full Self-Driving (FSD) mode on my 2023 Model 3. Below are the details of the specific behaviors observed: - Right turn on red almost crashed into an oncoming car from the left - Hard emergency brake due to a bird that was in..."

"Two separate incidents occurred on July 10th and July 12th 2026 involving adaptive cruise control. While adaptive cruise control was engaged my car slammed on the brakes for no reason. There was nothing in the roadway to cause abrupt braking. The second time it occurred my car was close to being..."

"Whilst driving on highways which feature multiple speed limits - eg. 70 cars, 65 Trucks, 60 Buses. If full self driving more or when in adaptive cruise control - the car systems fail to recognize the restriction linked to the lower speed limits. As a result, you can be driving on Full Self Drive at..."

"The steering rack in my 2023 Tesla Model 3 is defective and I can show it for inspection. 1.5 years ago it failed and the torque sensor in the rack is showing that there is a constant demand (even when parked and my hands off the wheel) to turn the wheel to the right that you can see in the cars..."

Lower Lateral Link detachment

The Office of Defects Investigation (ODI) has received 156 complaints alleging a suspension failure in model year (MY) 2018-2020 Model 3 and MY 2021-2023 Model Y vehicles. The suspension failure involves the detachment of the front lower lateral link, which potentially causes a loss of vehicle directional control. In most cases, there was no advance warning or indication that the suspension failure would occur.  Some cases cite noises occurring...

FSD Collisions in Reduced Roadway Visibility Conditions

The Office of Defects Investigation (ODI) is opening this Engineering Analysis to evaluate Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) degradation detection system. The focus of this investigation will be to assess the system’s ability, when encountering reduced roadway visibility conditions, to detect degradation and alert the driver with sufficient time to respond. ODI will evaluate the performance...

Traffic safety violations while Full Self Driving ("FSD") is engaged

The Office of Defects Investigation (“ODI”) is opening this Preliminary Evaluation (PE) to assess the scope, frequency, and potential safety consequences of FSD executing driving maneuvers that constitute traffic safety violations. This investigation concerns versions of FSD that Tesla has labeled as "FSD (Supervised)" and "FSD (Beta)." Tesla characterizes FSD as an SAE Level 2 partial automation system requiring a fully attentive driver who...

Compliance with Standing General Order 2021-01 Reporting Requirements

The Office of Defects Investigation (“ODI”) has identified numerous incident reports submitted by Tesla, Inc. (“Tesla”) in response to Standing General Order 2021-01 (the “SGO”), in which the reported crashes occurred several months or more before the dates of the reports. The majority of these reports involved crashes in which the Standing General Order in place at the time required a report to be submitted within one or five days of...

Recall 23V838 Remedy Effectiveness

The Office of Defects Investigation (ODI) is opening a Recall Query to assess the remedy adequacy of Recall 23V838. On December 12, 2023, Tesla filed a Defect Information Report (Recall 23V838) applicable to all Tesla models produced and equipped with any version of its Autopilot system, which Tesla described as an SAE Level 2 (L2) Advanced Driver Assistance System (ADAS). Autopilot is the simultaneous engagement of Tesla’s Traffic-Aware Cruise...

Sudden Unintended Acceleration

The Office of Defects Investigation (ODI) received a petition requesting that ODI reevaluate its decision to deny DP20-001 on the basis that intermittent high electrical current demands on the vehicles' 12VDC systems may have caused some or all of the incidents examined by ODI in DP20-001. The petitioner bases this information on a review of open-source research and the DP20-001 denial. The petition and related materials can be reviewed at NHTSA....

Actually Smart Summon sessions resulting in low-speed impacts.

On January 6, 2025, the Office of Defects Investigations (ODI) opened Preliminary Evaluation 24003 (PE24033) to investigate Actually Smart Summon (Summon) sessions resulting in crashes during active sessions. According to Tesla, Summon is a short-distance SAE Level 2 system, controlled by the user from a cell phone within a certain distance and intended for use in parking lots and on private property. ODI analyzed complaint data provided by Tesla...

FSD Collisions in Reduced Roadway Visibility Conditions

On October 17, 2024, NHTSA’s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24031) of Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) to assess: the ability of the FSD system to detect and respond appropriately to reduced roadway visibility conditions; whether any other FSD crashes had occurred under degraded roadway visibility conditions that are similar in nature to the four SG...

Loss of steering control

On July 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23014) to investigate instances of loss of electronic power-assisted steering in MY 2023 Tesla Model 3 and MY 2023 Tesla Model Y vehicles manufactured by Tesla, Inc. The complaints allege a sudden and unexpected inability to turn the steering wheel or an increase in effort required to turn the steering wheel. These conditions were alleged to occur both...

Loss of steering control

On July 28, 2023, The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23-014) after receiving 12 Vehicle Owner Questionnaires (VOQs) reporting loss of steering control in model years (MY) 2023 Tesla Model 3 and Y vehicles. During PE23-014, ODI interviewed complainants, sent an Information Request (IR) letter to Tesla, and convened technical meetings with Tesla that included a joint inspection of a crashed vehicle. The inv...

Defect Petition Interlock Request

On March 21, 2023, the Office of Defects Investigation (ODI) received a petition requesting a “recall of all Tesla cars” produced from 2013 to the date on which the petition was filed due to what Petitioner considers to be the increased likelihood of pedal misapplication. Attached to the Petition is a paper authored by Petitioner. According to Petitioner, the differences in the operator controls between the subject Tesla vehicles and internal...

Autopilot System Driver Controls

The Office of Defects Investigation (ODI) upgraded PE21020 to EA22002 on June 8, 2022, to extend work and deepen the PE21020 crash analysis, to supplement that analysis with additional data, and to perform vehicle evaluations to understand how Tesla’s Autopilot system may exacerbate human factors or behavioral safety risks by undermining the effectiveness of the driver’s supervision. To support this work, ODI collected additional crash inform...

Unexpected Brake Activation

On February 16, 2022, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE22002) to investigate reports of unexpected deceleration while driving with the adaptive cruise control system engaged in Model Year (MY) 2021 – 2022 Model 3 and Model Y vehicles manufactured by Tesla. The subject systems include Autopilot (all versions), Full Self-Driving (FSD) and Traffic Aware Cruise Control (TACC). These complaints have been c...