2022 Tesla Model S Problems & Defect Complaints

"This vehicle has a recurring suspension defect causing a chassis or suspension component to make physical contact with the inner shoulder of the rear tires during normal operation, producing a sharp linear cut progressing to full cord exposure and fraying of internal steel and aramid belts. This..."

"Turn signal inaccessible."

"See attached document for complaint."

"The vehicle was being driven northbound in the regular (non-HOV) lanes of Route I-95 under the control of Version 12 of FSD software. I believe that the vehicle would have crashed into the lowered gates preventing vehicles from entering the HOV lanes, which operate in only one direction at a time...."

"This car does not have reliable horn system. I have the steering wheel version (not the “yoke” version) but I believe it’s a similar problem on both. The steering wheel center (airbag) does NOT operate as a horn. Instead there is only a extremely small horn sensor on one side of the wheel that..."

FSD Collisions in Reduced Roadway Visibility Conditions

The Office of Defects Investigation (ODI) is opening this Engineering Analysis to evaluate Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) degradation detection system. The focus of this investigation will be to assess the system’s ability, when encountering reduced roadway visibility conditions, to detect degradation and alert the driver with sufficient time to respond. ODI will evaluate the performance...

Traffic safety violations while Full Self Driving ("FSD") is engaged

The Office of Defects Investigation (“ODI”) is opening this Preliminary Evaluation (PE) to assess the scope, frequency, and potential safety consequences of FSD executing driving maneuvers that constitute traffic safety violations. This investigation concerns versions of FSD that Tesla has labeled as "FSD (Supervised)" and "FSD (Beta)." Tesla characterizes FSD as an SAE Level 2 partial automation system requiring a fully attentive driver who...

Compliance with Standing General Order 2021-01 Reporting Requirements

The Office of Defects Investigation (“ODI”) has identified numerous incident reports submitted by Tesla, Inc. (“Tesla”) in response to Standing General Order 2021-01 (the “SGO”), in which the reported crashes occurred several months or more before the dates of the reports. The majority of these reports involved crashes in which the Standing General Order in place at the time required a report to be submitted within one or five days of...

Recall 23V838 Remedy Effectiveness

The Office of Defects Investigation (ODI) is opening a Recall Query to assess the remedy adequacy of Recall 23V838. On December 12, 2023, Tesla filed a Defect Information Report (Recall 23V838) applicable to all Tesla models produced and equipped with any version of its Autopilot system, which Tesla described as an SAE Level 2 (L2) Advanced Driver Assistance System (ADAS). Autopilot is the simultaneous engagement of Tesla’s Traffic-Aware Cruise...

Sudden Unintended Acceleration

The Office of Defects Investigation (ODI) received a petition requesting that ODI reevaluate its decision to deny DP20-001 on the basis that intermittent high electrical current demands on the vehicles' 12VDC systems may have caused some or all of the incidents examined by ODI in DP20-001. The petitioner bases this information on a review of open-source research and the DP20-001 denial. The petition and related materials can be reviewed at NHTSA....

Actually Smart Summon sessions resulting in low-speed impacts.

On January 6, 2025, the Office of Defects Investigations (ODI) opened Preliminary Evaluation 24003 (PE24033) to investigate Actually Smart Summon (Summon) sessions resulting in crashes during active sessions. According to Tesla, Summon is a short-distance SAE Level 2 system, controlled by the user from a cell phone within a certain distance and intended for use in parking lots and on private property. ODI analyzed complaint data provided by Tesla...

FSD Collisions in Reduced Roadway Visibility Conditions

On October 17, 2024, NHTSA’s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24031) of Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) to assess: the ability of the FSD system to detect and respond appropriately to reduced roadway visibility conditions; whether any other FSD crashes had occurred under degraded roadway visibility conditions that are similar in nature to the four SG...

Defect Petition Interlock Request

On March 21, 2023, the Office of Defects Investigation (ODI) received a petition requesting a “recall of all Tesla cars” produced from 2013 to the date on which the petition was filed due to what Petitioner considers to be the increased likelihood of pedal misapplication. Attached to the Petition is a paper authored by Petitioner. According to Petitioner, the differences in the operator controls between the subject Tesla vehicles and internal...

Front seat belt anchor detachment

On March 24, 2023, the Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE) after receiving 2 consumer complaints alleging the front seat belts had suddenly detached from the outboard lap pretensioner anchor while in motion in model year (MY) 2022-2023 Tesla Model X vehicles. In its June 19, 2023 response to ODI’s May 4, 2023 Information Request letter of the PE, Tesla reported that its review of field repair data ident...

Pedestrian alert sounds

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight ra...

Autopilot System Driver Controls

The Office of Defects Investigation (ODI) upgraded PE21020 to EA22002 on June 8, 2022, to extend work and deepen the PE21020 crash analysis, to supplement that analysis with additional data, and to perform vehicle evaluations to understand how Tesla’s Autopilot system may exacerbate human factors or behavioral safety risks by undermining the effectiveness of the driver’s supervision. To support this work, ODI collected additional crash inform...

Unexpected Brake Activation

On February 16, 2022, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE22002) to investigate reports of unexpected deceleration while driving with the adaptive cruise control system engaged in Model Year (MY) 2021 – 2022 Model 3 and Model Y vehicles manufactured by Tesla. The subject systems include Autopilot (all versions), Full Self-Driving (FSD) and Traffic Aware Cruise Control (TACC). These complaints have been c...

Autopilot & First Responder Scenes

On August 13, 2021, NHTSA?s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE21-020) to assess the performance of Tesla?s Autopilot system (a system characterized by Tesla as an SAE Level 2 driving automation system designed to support and assist the driver in performing the driving task) available in Tesla vehicles. The investigation opening was motivated by an accumulation of crashes in which Tesla vehicles, operating wi...