2024 Tesla Model S Problems & Defect Complaints

"2024 Tesla Model S. Repeated rear tire and rear wheel failures with abnormal wear and possible rear alignment or suspension-related defect. Tesla service history shows repeated rear tire replacements beginning at about 5,165 miles, a later four-wheel alignment, a right rear tire replacement for..."

"The contact owns a 2024 Tesla Model S. The contact stated that after an update was performed over the air (OTA), the scroll option changed, and the contact was unable to control the speed of the vehicle. There was no longer a maximum speed limit. The local dealer was not contacted. The vehicle was..."

"The design of the emergency opening (No power to normal opening system) of the rear passenger doors is flawed, unsafe and should never have been approved for production. This rear door emergency opening requires an occupant to reach below the seat, remove carpet and pull a manual release cable...."

"Sometimes while making ordinary and safe traffic maneuvers the Lane Departure Warning system sometimes emits a very loud, distracting, and startling emergency chime. In particular it does this while turning into parking garages or driveways, which are already high-workload moments with high..."

"My car is displaying a message that the "Front left safety restraint issue". Airbags are off. brought the car in for service, they said they fixed some low voltage pin. Less than a week later the message appeared again. Tesla did not take this issue seriously -- I'm driving around with no airbags?..."

FSD Collisions in Reduced Roadway Visibility Conditions

The Office of Defects Investigation (ODI) is opening this Engineering Analysis to evaluate Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) degradation detection system. The focus of this investigation will be to assess the system’s ability, when encountering reduced roadway visibility conditions, to detect degradation and alert the driver with sufficient time to respond. ODI will evaluate the performance...

Traffic safety violations while Full Self Driving ("FSD") is engaged

The Office of Defects Investigation (“ODI”) is opening this Preliminary Evaluation (PE) to assess the scope, frequency, and potential safety consequences of FSD executing driving maneuvers that constitute traffic safety violations. This investigation concerns versions of FSD that Tesla has labeled as "FSD (Supervised)" and "FSD (Beta)." Tesla characterizes FSD as an SAE Level 2 partial automation system requiring a fully attentive driver who...

Compliance with Standing General Order 2021-01 Reporting Requirements

The Office of Defects Investigation (“ODI”) has identified numerous incident reports submitted by Tesla, Inc. (“Tesla”) in response to Standing General Order 2021-01 (the “SGO”), in which the reported crashes occurred several months or more before the dates of the reports. The majority of these reports involved crashes in which the Standing General Order in place at the time required a report to be submitted within one or five days of...

Recall 23V838 Remedy Effectiveness

The Office of Defects Investigation (ODI) is opening a Recall Query to assess the remedy adequacy of Recall 23V838. On December 12, 2023, Tesla filed a Defect Information Report (Recall 23V838) applicable to all Tesla models produced and equipped with any version of its Autopilot system, which Tesla described as an SAE Level 2 (L2) Advanced Driver Assistance System (ADAS). Autopilot is the simultaneous engagement of Tesla’s Traffic-Aware Cruise...

Actually Smart Summon sessions resulting in low-speed impacts.

On January 6, 2025, the Office of Defects Investigations (ODI) opened Preliminary Evaluation 24003 (PE24033) to investigate Actually Smart Summon (Summon) sessions resulting in crashes during active sessions. According to Tesla, Summon is a short-distance SAE Level 2 system, controlled by the user from a cell phone within a certain distance and intended for use in parking lots and on private property. ODI analyzed complaint data provided by Tesla...

FSD Collisions in Reduced Roadway Visibility Conditions

On October 17, 2024, NHTSA’s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24031) of Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) to assess: the ability of the FSD system to detect and respond appropriately to reduced roadway visibility conditions; whether any other FSD crashes had occurred under degraded roadway visibility conditions that are similar in nature to the four SG...